近年來，
濟南彩鋼板在我們生活中的利用率越來越高。他的使用能顯示出良好的生產力。彩鋼板具有良好的保溫效果，但也不是沒有缺陷。長時間容易生銹，導致涂層剝落，影響正常使用。接下來，我想介紹一下如何處理生銹的彩色鋼板。
In recent years, Jinan color steel plate in our life more and more high utilization. His use can show good productivity. Color steel plate has good heat preservation effect, but it is not without defects. It is easy to rust for a long time, resulting in coating peeling off and affecting normal use. Next, I would like to introduce how to deal with rusty colored steel plate.
1、彩鋼板細部節點處理：
1. Treatment of detail joints of color steel plate:
(1)將彩鋼板的固定部位重新鉚接在屋脊罩上，彩鋼板在屋脊罩上凸出，彩鋼板與照明帶的連接處出現縫隙。
(1) The fixed part of the color steel plate is riveted on the roof ridge cover again. The color steel plate protrudes on the roof ridge cover, and there is a gap between the color steel plate and the lighting belt.
(2)緊固件應緊固在屋頂系統緊固件不在的地方。
(2) Fasteners should be fastened where the roof system fasteners are not available.
(3)修整屋頂板的滴水處、壓條和封邊，確保所有鋼構件和配件緊密貼合。
(3) Trim dripping, taping and edging of roof slab to ensure that all steel members and fittings fit closely.
(4)對于一些細節部分，應在詳細處理時分別進行拆除和整改。
(4) For some details, they should be removed and rectified respectively during detailed treatment.
2、基層清理及處理：
2. Base cleaning and treatment:
(1)、拆除工作完成后，應對防水基層進行處理。
(1) After the demolition, the waterproof base should be treated.
(2)、彩鋼板接頭部分和固定螺絲部分用刷子反復處理，直干凈;
(2) The joint part of color steel plate and the fixing screw part are repeatedly treated with a brush until they are clean;
(3)、基層清理和處理工作根據防水施工進度要求分別完成，以免因不及時施工而造成二次污染，需要再次清理;
(3) The base cleaning and treatment work shall be completed according to the waterproof construction schedule, so as to avoid secondary pollution caused by delayed construction and need to be cleaned up again;
(4)、將大量高的屋面密封膠，重新修補;
(4) Remove a large amount of high roof sealant and repair it again;
(5)、屋面施工前，需要先做密封膠施工，然后做附加層施工，然后整體施工。在上述工作修復之前，整體屋頂?shù)恼彰鲙Р坏梅浪?/div>
(5) Before roof construction, sealant construction, additional layer construction and overall construction are required. The lighting strip of the whole roof shall not be waterproof until the above work is repaired
確保待安裝的濟南彩鋼板的實際長度和相應彩鋼板編號的長度應該非常清楚。板子的位置非常重要，應該放在正確的位置。檐口應加襯，后面板應平行于前面板并垂直于檁條。墻板無論檁條是否水平偏移，墻板應垂直排列，搭接處應協調一致，螺紋采用自攻釘，板與板之間的連接應增加自攻釘。
Ensure that the actual length of Jinan color steel plate to be installed and the length of corresponding color steel plate number should be very clear. The position of the board is very important and should be placed in the right position. Cornice shall be lined and back panel shall be parallel to front panel and perpendicular to purlin. No matter whether the purlin is horizontal offset or not, the wallboard should be arranged vertically, the lap joint should be consistent, the screw thread should be self tapping screw, and the connection between plate and plate should be added with self tapping screw.
保溫棉鋪設應保持連續性。每個人都不應該過度擰緊自攻螺釘，因為過度擰緊會降低墊片的密封性能。在嚴重的情況下，印板塊的表面會下沉，水就會進入。彩板縱向搭接時，應按設計鋪設密封條和密封膠，搭接時用自攻螺釘或墊片拉鉚釘連接。應拉動密封條上的緊固件。
The laying of insulation cotton should be continuous. Everyone should not overtighten the self tapping screw, as over tightening will reduce the sealing performance of the gasket. In severe cases, the surface of the plate will sink and water will enter. When the color plate is longitudinally overlapped, the sealing strip and sealant shall be laid according to the design, and the self tapping screw or gasket rivet shall be used for connection. The fasteners on the weatherstrip should be pulled.
這是今天彩鋼板制造商介紹的解決濟南彩鋼板銹蝕的相關內容。我相信當每個人都愿意這樣做的時候，他們就會知道一些事情。如果有必要，他們可以稍后通過電話聯系我們。
This is the related content introduced by the color steel plate manufacturer to solve the corrosion of Jinan color steel plate. I believe that when everyone is willing to do so, they will know something. If necessary, they can contact us by phone later.
