Nowadays, we can often see the figure of Jinan color steel plate in the construction industry. It can provide people with residence and play a very important role in daily life. How much do you know about its anti-corrosion spraying techniques? Do you know what? Jinan color steel plate is introduced below, hoping to help you.

其防腐涂料可有效延長彩鋼板的使用年限，而普通油漆只能起到臨時表面掩蓋的作用，很快將會出現爆皮及脫落現象，不能從根本上解決銹蝕問題，阻止生銹現象的發生。八大噴涂技巧如下所示：

The anti-corrosion coating can effectively extend the service life of color steel plate, while the ordinary paint can only play a temporary surface covering role, and the phenomenon of skin burst and falling off will appear soon, which can not fundamentally solve the corrosion problem and prevent the occurrence of rust phenomenon. The eight painting techniques are as follows:

濟南彩鋼板

Jinan color steel plate

1、按產品規定配比配制涂料，并攪拌均勻，熟化時間控制在30分鐘，在6小時內施工完畢，涂裝間隔短不能小于24小時，長不大于7天。

1. The coating shall be prepared according to the specified proportion of the product, and evenly stirred. The curing time shall be controlled within 30 minutes. The construction shall be completed within 6 hours. The coating interval shall not be less than 24 hours and the length shall not be more than 7 days.

2、施工所用工具應清潔干燥，涂料不得混有水分、香蕉水、醇類溶劑、汽油等及其它雜質，涂料現配現用，須在6小時內噴涂完畢，以防止結膠，造成不必要的損失，提高施工成本。

2. The tools used in the construction shall be clean and dry, and the coating shall not be mixed with moisture, banana water, alcohol solvent, gasoline and other impurities. The coating shall be sprayed within 6 hours when it is ready for use, so as to prevent glue formation, cause unnecessary loss and increase construction cost.

3、彩鋼板廠家建議先采用水槍沖洗彩鋼板，然后角向磨光機、鋼絲刷、鐵砂布等工具將基面灰塵、污垢、毛刺、水漬、油脂和老化的漆層等附著物清洗干凈。

3. The manufacturer of color steel plate suggests that the color steel plate should be washed with water gun first, and then the dust, dirt, burr, water stain, grease and aged paint layer on the base surface shall be cleaned by angular polishing machine, wire brush, iron sand cloth and other tools.

4、噴涂施工前用毛刷或壓縮空氣格表面、陰角、溝槽的粉塵干凈。

4. Before spraying, the dust on the surface, inner corner and groove of the grid shall be cleaned with brush or compressed air.

5、基面清理后經合格后可進行噴涂層施工。

5. The spraying layer can be applied after the base surface is cleaned and qualified.

6、確認無漏除、無銹粉的情況下進行涂層施工。

6. Coating construction shall be carried out without leakage and rust powder.

7、為防止二次污染，在基面處理后立即噴涂一遍。

7. In order to prevent secondary pollution, spray once immediately after base surface treatment.

8、施工溫度在5度-35度，相對濕度百分之85，在有雨、霧、雪和較大灰塵條件下不可施工。

8. The construction temperature is between 5 ℃ and 35 ℃, and the relative humidity is 85%. The construction can not be carried out under the conditions of rain, fog, snow and large dust.

延長彩鋼板使用壽命的做法

Practice of prolonging service life of color steel plate

1、一般彩鋼板在風吹雨打幾年之后就會呈現銹斑、腐蝕。假如想讓彩鋼板延伸壽數怎么做呢?能夠每平米涂料用量不低于1公斤。在不明顯進步施工本錢的情況下，可少延伸彩鋼板使用壽數5~8年這樣延伸壽數，下降施工本錢。

1. Generally, the color steel plate will show rust spots and corrosion after several years of wind and rain. If you want to let color steel plate extend life how to do? Can each square meter coating dosage not less than 1 kg. If the construction cost is not significantly improved, the service life of color steel plate can be extended for at least 5-8 years, which will reduce the construction cost.

2、要是彩鋼板外表已經有生銹腐蝕的痕跡時就要打磨機或許砂紙將外表的浮銹打磨潔凈，這些方法都能夠?qū)⒉输摪宸浪墓δ苓M(jìn)步，讓彩鋼板不在被腐蝕，決裂。彩鋼板為什么會漏水呢?有以下幾種或許，彩鋼板的斜度小，保溫層的露出，裝置時不作相應的處理，導致雨水直流進保溫夾層，形成了所有為的雨水倒流。

2. If there are signs of rust and corrosion on the surface of the color steel plate, a grinding machine or sandpaper should be used to polish the surface rust. These methods can improve the waterproof function of the color steel plate, so that the color steel plate will not be corroded and cracked. Why does the color steel plate leak? There are several possibilities. The slope of the color steel plate is small, the insulation layer is exposed, and the corresponding treatment is not made during the installation, which leads to the direct flow of rainwater into the insulation interlayer, forming all the rainwater backflow.

3、彩鋼板接縫很會導致彩鋼板漏水，接縫時，看上去很好，但一條長長的縫隙經不起一小時的雨水沖刷，滲漏將渾水摸魚。彩鋼板裝置時的釘子眼，也是漏水的直接原因，所以不只要產品質量好，并且裝置的技能也要到位。

3. The seam of color steel plate will lead to water leakage of color steel plate. When the joint is made, it looks very good, but a long gap can't withstand an hour of rain washing, and the leakage will fish in troubled waters. The nail hole in the installation of color steel plate is also the direct cause of water leakage, so not only the product quality is good, but also the installation skills should be in place.

濟南彩鋼板

Jinan color steel plate

以上就是彩鋼板廠家為大家介紹的關于濟南彩鋼板的八個防腐噴涂技巧以及保養的全部內容，相信大家看后也會有所了解，希望上述內容能對大家有所幫助，想了解更多詳情，可以關注網站或者電話聯系我們，隨時歡迎大家前來參觀選購。

The above is all about the eight anti-corrosion spraying techniques and maintenance of Jinan color steel plate introduced by the manufacturer of color steel plate. I believe you will understand after reading. I hope the above content can help you. If you want to know more details, you can pay attention to the website or contact us by phone. You are welcome to visit and purchase at any time.